Isobutan Chemische Eigenschaften,Einsatz,Produktion Methoden
ERSCHEINUNGSBILD
FARBLOSES KOMPRIMIERTES FLüSSIGGAS MIT CHARAKTERISTISCHEM GERUCH.
PHYSIKALISCHE GEFAHREN
Das Gas ist schwerer als Luft und kann sich am Boden ausbreiten. Fernzündung m?glich. Flie?en, Schütten o.?. kann zu elektrostatischer Aufladung führen.
CHEMISCHE GEFAHREN
Reagiert mit starken Oxidationsmitteln, Acetylen, Halogenen und Stickstoffoxiden unter Feuer- und Explosionsgefahr.
ARBEITSPLATZGRENZWERTE
TLV (Aliphatische Kohlenwasserstoff-Gase, Alkan C1-C4): 1000 ppm (als TWA) (ACGIH 2005).
MAK: 1000 ppm, 2400 mg/m? Spitzenbegrenzung: überschreitungsfaktor II(4); Schwangerschaft: Gruppe D (DFG 2008).
AUFNAHMEWEGE
Aufnahme in den K?rper durch Inhalation.
INHALATIONSGEFAHREN
Eine gesundheitssch?dliche Konzentration des Gases in der Luft wird beim Entweichen aus dem Beh?lter sehr schnell erreicht.
WIRKUNGEN BEI KURZZEITEXPOSITION
WIRKUNGEN BEI KURZZEITEXPOSITION: Schnelle Verdampfung kann zu Erfrierungen führen. M?glich sind Auswirkungen auf das Herzkreislaufsystem mit nachfolgenden Funktionsst?rungen und Atemversagen. Exposition gegenüber hohen Konzentrationen kann zum Tod führen.
LECKAGE
Gefahrenbereich verlassen! Fachmann zu Rate ziehen! Belüftung. Zündquellen entfernen. Wasserstrahl NIEMALS auf die Flüssigkeit richten. Pers?nliche Schutzausrüstung: Atemschutzfilter für organische D?mpfe niedrigsiedender Verbindungen.
R-S?tze Betriebsanweisung:
R12:Hochentzündlich.
S-S?tze Betriebsanweisung:
S9:Beh?lter an einem gut gelüfteten Ort aufbewahren.
S16:Von Zündquellen fernhalten - Nicht rauchen.
Chemische Eigenschaften
2-Methylpropane (isobutane), C4H10, a flammable gas,
occurs in small quantities in natural gas and crude oil. It
has been detected in urban atmospheres at concentrations of
44–74 ppb. It also evolves from natural sources and
has been measured in diesel exhaust at 1.4–11 ppm
and in cigarette smoke at 10 ppm. The partition
coefficient of propane between olive oil and air at 37℃ is
12 using the method described by Sato and Nakajima and
Perbellini et al.. The lower explosive limit is
18,000 ppm in air.
Verwenden
Isobutane occurs in petroleum, natural gas,and petroleum cracking products. It is usedas a fuel gas or a liquefied petroleum gas. Itis also used in organic synthesis.
Definition
ChEBI: An alkane that is propane substituted by a methyl group at position 2.
Allgemeine Beschreibung
ISOBUTANE is a colorless gas with a faint petroleum-like odor. ISOBUTANE is shipped as a liquefied gas under its vapor pressure. Contact with the liquid can cause frostbite. ISOBUTANE is easily ignited. The vapors are heavier than air. Any leak can either be liquid or vapor. ISOBUTANE can asphyxiate by the displacement of air. Under prolonged exposure to fire or intense heat the containers may rupture violently and rocket.
Air & Water Reaktionen
Highly flammable.
Reaktivit?t anzeigen
ISOBUTANE is incompatible with the following: Strong oxidizers (e.g., nitrates & perchlorates), chlorine, fluorine, (nickel carbonyl + oxygen) .
Hazard
Highly flammable, dangerous fire and
explosive risk; explosive limits in air 1.9–8.5%.
Health Hazard
Isobutane, like other saturated aliphatic alkanes,is nontoxic. It is an asphyxiate. Exposureto high concentrations of 1% in air maycause narcosis and drowsiness. Other thanthis, there is no report of any adverse healtheffect from exposure to this gas.
Brandgefahr
EXTREMELY FLAMMABLE. Will be easily ignited by heat, sparks or flames. Will form explosive mixtures with air. Vapors from liquefied gas are initially heavier than air and spread along ground. CAUTION: Hydrogen (UN1049), Deuterium (UN1957), Hydrogen, refrigerated liquid (UN1966) and Methane (UN1971) are lighter than air and will rise. Hydrogen and Deuterium fires are difficult to detect since they burn with an invisible flame. Use an alternate method of detection (thermal camera, broom handle, etc.) Vapors may travel to source of ignition and flash back. Cylinders exposed to fire may vent and release flammable gas through pressure relief devices. Containers may explode when heated. Ruptured cylinders may rocket.
Sicherheitsprofil
An asphyxiant. A
common air contaminant. A very dangerous
fire and explosion hazard when exposed to
heat, flame, or oxidizers. To fight fire, stop
flow of gas. When heated to decomposition
it emits acrid smoke and irritating fumes.
Environmental Fate
Photolytic. Based upon a photooxidation rate constant of 2.34 x 10
-12 cm
3/moleculesec with OH
radicals in summer daylight, the atmospheric lifetime is 59 h (Altshuller, 1991). At atmospheric
pressure and 300 K, Darnall et al. (1978) reported a rate constant of 2.52 x 10
-12 cm
3/moleculesec
for the same reaction. Rate constants of 1.28 x 10
-9 and 6.03 x 10
-12 L/moleculesec were reported
for the reaction of 2-methylpropane with OH radicals in air at 300 and 296 K, respectively
(Greiner, 1967, 1970). Rate constants of 7.38 x 10
-13 and 6.50 x 10
-17 cm
3/moleculesec were
reported for the reaction of 2-methylpropane with OH and NO3, respectively (Sablji and Güsten,
1990).
Chemical/Physical. Complete combustion in air produces carbon dioxide and water vapor. 2-
Methylpropane will not hydrolyze because it does not contain a hydrolyzable functional group.
l?uterung methode
Olefins and moisture can be removed by passage at 65o through a bed of silica-alumina catalyst which has previously been evacuated at about 400o. Alternatively, water and CO2 can be removed by passage through P2O5, then asbestos impregnated with NaOH. Treatment with anhydrous AlBr3 at 0o then removes traces of olefins. Inert gases can be separated by freezing the isobutane at -195o and evacuating out the system. [Beilstein 1 IV 282.]
Isobutan Upstream-Materialien And Downstream Produkte
Upstream-Materialien
Downstream Produkte
