Tetramethylorthosilicat Chemische Eigenschaften,Einsatz,Produktion Methoden
ERSCHEINUNGSBILD
FARBLOSE FLüSSIGKEIT
ARBEITSPLATZGRENZWERTE
TLV: 1 ppm (als TWA); (ACGIH 2005).
MAK nicht festgelegt (DFG 2005).
AUFNAHMEWEGE
Aufnahme in den K?rper durch Inhalation der D?mpfe und durch Verschlucken.
INHALATIONSGEFAHREN
Beim Verdampfen bei 20°C kann sehr schnell eine gesundheitssch?dliche Kontamination der Luft eintreten.
WIRKUNGEN BEI KURZZEITEXPOSITION
WIRKUNGEN BEI KURZZEITEXPOSITION: Die Substanz reizt stark die Augen, die Haut und die Atemwege. Inhalation von Dampf kann zu Lungen?dem führen (s.Anm.). Die Auswirkungen treten u.U. verz?gert ein. ?rztliche Beobachtung notwendig.
WIRKUNGEN NACH WIEDERHOLTER ODER LANGZEITEXPOSITION
M?glich sind Auswirkungen auf Nieren und Leber.
LECKAGE
Ausgelaufene Flüssigkeit m?glichst in abdichtbaren Beh?ltern sammeln. Reste sorgf?ltig sammeln. An sicheren Ort bringen. Pers?nliche Schutzausrüstung: Chemikalienschutzanzug mit umgebungsluftunabh?ngigem Atemschutzger?t.
R-S?tze Betriebsanweisung:
R10:Entzündlich.
R26:Sehr giftig beim Einatmen.
R37/38:Reizt die Atmungsorgane und die Haut.
R41:Gefahr ernster Augensch?den.
S-S?tze Betriebsanweisung:
S16:Von Zündquellen fernhalten - Nicht rauchen.
S26:Bei Berührung mit den Augen sofort gründlich mit Wasser abspülen und Arzt konsultieren.
S36/37/39:Bei der Arbeit geeignete Schutzkleidung,Schutzhandschuhe und Schutzbrille/Gesichtsschutz tragen.
S45:Bei Unfall oder Unwohlsein sofort Arzt zuziehen (wenn m?glich, dieses Etikett vorzeigen).
Chemische Eigenschaften
Tetramethyl orthosilicate (TMOS), the methyl ester of orthosilicic acid, is a colorless, low-viscosity liquid. It is industrially the most important of the tetraalkyl silicates.
Verwenden
Tetramethyl Orthosilicate is a compound used in the research of the multifunctionality of silicified nanoshells and the efficiency at adsorbing cadmium ions at cell interfaces.
Vorbereitung Methode
Silica aerogels are usually prepared by base-catalyzed reaction
of tetramethoxysilane or tetraethoxysilane, mostly with
ammonia as the catalyst. A modification of this procedure is
to prehydrolyze Si(OR)4 with a small amount of water under
acidic conditions.
Allgemeine Beschreibung
A clear colorless liquid. Flash point below 125°F. Less dense than water and insoluble in water. Very toxic by ingestion and inhalation and very irritating to skin and eyes. Used to make paints and lacquers.
Air & Water Reaktionen
Flammable. Insoluble in water.
Reaktivit?t anzeigen
Tetramethyl orthosilicate is incompatible with the following: Oxidizers; hexafluorides of rhenium, molybdenum & tungsten .
Hazard
Eye damage and upper respiratory tract irri-tant.
Health Hazard
TOXIC; inhalation, ingestion or contact (skin, eyes) with vapors, dusts or substance may cause severe injury, burns or death. Bromoacetates and chloroacetates are extremely irritating/lachrymators. Reaction with water or moist air will release toxic, corrosive or flammable gases. Reaction with water may generate much heat that will increase the concentration of fumes in the air. Fire will produce irritating, corrosive and/or toxic gases. Runoff from fire control or dilution water may be corrosive and/or toxic and cause pollution.
Brandgefahr
HIGHLY FLAMMABLE: Will be easily ignited by heat, sparks or flames. Vapors form explosive mixtures with air: indoors, outdoors and sewers explosion hazards. Most vapors are heavier than air. They will spread along ground and collect in low or confined areas (sewers, basements, tanks). Vapors may travel to source of ignition and flash back. Substance will react with water (some violently) releasing flammable, toxic or corrosive gases and runoff. Contact with metals may evolve flammable hydrogen gas. Containers may explode when heated or if contaminated with water.
Sicherheitsprofil
Poison by
intraperitoneal route. Moderately toxic by
inhalation. Midly toxic by skin contact. A
severe eye irritant. This material can cause extensive necrosis (experimentally),
keratoconus, and opaque cornea. It also
causes severe human eye injuries, as well as
necrosis of corneal cells, which progresses
long after exposure has ceased. It is
destructive and its effects resist treatment.
Permanent blindness is possible from
exposure to it. The kidney seems to be most
subject to injury regardless of the mode of
exposure. Pulmonary edema has also
occurred. This material is more toxic than
either ethyl silicate or silicic acid, although it
has been thought that the injury caused is
largely due to the action of the silicic acid.
Flammable when exposed to heat or flame;
can react vigorously with oxidizing
materials. Potentially violent reaction with
metal hexafluorides (e.g., rhenium,
molybdenum, tungsten). When heated to
decomposition it emits acrid smoke and
irritating fumes.
m?gliche Exposition
Methyl silicate is used in coating
screens of television picture tubes. It may be used in mold
binders and in corrosion-resistant coatings; as well as in
catalyst preparation and as a silicone intermediate.
Versand/Shipping
UN2606 Methyl orthosilicate, Hazard class: 6.1;
Labels: 6.1-Poisonous materials, 3-Flammable liquid.
l?uterung methode
Purification is as for tetraethoxysilane. It has a vapour pressure of 2.5mm at 0o. [IR: Sternbach & MacDiarmid J Am Chem Soc 81 5109 1959. Beilstein 1 IV 1266.]
Inkompatibilit?ten
Vapor may form explosive mixture with
air. Incompatible with oxidizers (chlorates, nitrates, peroxides, permanganates, perchlorates, chlorine, bromine, fluorine, etc.); contact may cause fires or explosions. Keep
away from alkaline materials, including alkaline earth
metals, metals, strong acids, strong bases; water, moisture,
steam decomposes releasing toxic, flammable gases.
Violent reaction with metal hexafluorides of rhenium,
molybdenum, and tungsten. Contact with metals may
evolve flammable hydrogen gas.
Tetramethylorthosilicat Upstream-Materialien And Downstream Produkte
Upstream-Materialien
Downstream Produkte
Trimethylborat
tris(Trimethylsilyloxy)silanol
P-fluorophenyltriMethoxysilane
Tetrapropylorthosilicat
Trimethoxy(3,3,3-trifluorpropyl)silan
Methyl-p-toluat
Tetrahydroxysilan
1,1-Dimethoxy-3,7-dimethylocta-2,6-dien
1,1,5,5,5-Hexamethyl-3,3-bis[(trimethylsilyl)oxy]trisiloxan
Tetrakis(1-methylethyl)orthosilicat
2,2-Dimethoxybutane
CHLOROMETHYL METHYL SULFIDE
